NO Removal in Continuous BioDeNOx Reactors: Fe(II)EDTA2- Regeneration, Biomass Growth, and EDTA Degradation

P.M.F. van der Maas, P. van den Brink, S. Utomo, A. Klapwijk, P.N.L. Lens

Research output: Contribution to journalArticleAcademicpeer-review

42 Citations (Scopus)

Abstract

BioDeNOx is a novel technique for NOx removal from industrial flue gases. In principle, BioDeNOx is based on NO absorption into an aqueous Fe(II)EDTA2- solution combined with biological regeneration of that scrubber liquor in a bioreactor. The technical and economical feasibility of the BioDeNOx concept is strongly determined by high rate biological regeneration of the aqueous Fe(II)EDTA2- scrubber liquor and by EDTA degradation. This investigation deals with the Fe(II)EDTA2- regeneration capacity and EDTA degradation in a lab-scale BioDeNOx reactor (10-20 mM Fe(II)EDTA2-, pH 7.2 ± 0.2, 55°C), treating an artificial flue gas (1.5 m3/h) containing 60-155 ppm NO and 3.5-3.9% O2. The results obtained show a contradiction between the optimal redox state of the aqueous FeEDTA solution for NO absorption and the biological regeneration. A low redox potential (below -150 mV vs. Ag/AgCl) is needed to obtain a maximal NO removal efficiency from the gas phase via Fe(II)EDTA2- absorption. Fe(III)EDTA- reduction was found to be too slow to keep all FeEDTA in the reduced state. Stimulation of Fe(III)EDTA- reduction via periodical sulfide additions (2 mM spikes twice a week for the conditions applied in this study) was found to be necessary to regenerate the Fe(II)EDTA2- scrubber liquor and to achieve stable operation at redox potentials below -150 mV (pH 7.2 ± 0.2). However, redox potentials of below -200 mV should be avoided since sulfide accumulation is unwanted because it is toxic for NO reduction. Very low values for biomass growth rate and yield, respectively, 0.043/d and 0.009 mg protein per mg ethanol, were observed. This might be due to substrate limitations, that is the electron acceptors NO and presumably polysulfide, or to physiological stress conditions induced by the EDTA rich medium or by radicals formed in the scrubber upon the oxidation of Fe(II)EDTA2- by oxygen present in the flue gas. Radicals possibly also induce EDTA degradation, which occurs at a substantial rate: 2.1 (±0.1) mM/d under the conditions investigated
Original languageEnglish
Pages (from-to)575-584
JournalBiotechnology and Bioengineering
Volume94
Issue number3
DOIs
Publication statusPublished - 2006

Keywords

  • nitric-oxide
  • ethylenediaminetetraacetic acid
  • biological denitrification
  • reduction
  • absorption
  • iron
  • methanogenesis
  • oxidation
  • kinetics
  • sulfide

Fingerprint

Dive into the research topics of 'NO Removal in Continuous BioDeNOx Reactors: Fe(II)EDTA2- Regeneration, Biomass Growth, and EDTA Degradation'. Together they form a unique fingerprint.

Cite this